![Ariens ST24LE COMPACT [31/42] Friction disc replacement](/img/pdf.png)
Ariens ST24LE COMPACT [31/42] Friction disc replacement
![Ariens ST24 COMPACT TRACK [31/42] Friction disc replacement](/views2/1509896/page31/bg1f.png)
GB - 31
TRACTION DRIVE BELT
REPLACEMENT
(Figures 38)
NOTE: Housing and frame must be tipped
apart and attachment drive belt removed from
engine sheave in order to change traction
drive belt.
1. Remove attachment drive belt (See
Remove Attachment Drive Belt on
page 29).
2. Remove swing gate spacer.
3. Slide drive plate to the left until finger is
out of the frame.
NOTE: The drive plate is detached to create
space between the drive plate and friction
disc to remove and reinstall the belt.
4. Detach traction idler spring.
5. Remove traction drive belt.
NOTE: To remove belt it may be necessary to
turn crankshaft pulley using recoil starter
handle.
6. Replace traction drive belt.
7. Swing drive plate toward friction disc
and slide finger into stop hole in frame.
8. Reinstall swing gate spacer.
NOTE: Make sure drive plate spring remains
connected to the frame and drive plate.
9. Replace attachment drive belt (See
Replace Attachment Drive Belt on
page 30).
FRICTION DISC REPLACEMENT
Remove Friction Disc
(Figure 39)
1. Shut off engine, remove key, disconnect
spark plug wire and allow unit to cool
completely.
2. Place the unit into the service position
on a level surface.
3. Remove lockpins from wheel axles and
remove wheels.
4. Remove bottom cover by removing six
hex bolts.
5. Disconnect pivot pin from the speed
selector arm. Save the hardware for
reinstallation.
6. Remove spring hairpin nearest drive
gear from hex shaft.
7. Remove left bearing flange from frame.
8. Slide hex shaft to the left to remove the
flat washer, pinion gear and friction disc
assembly from the hex shaft.
NOTE: Be sure to save washers between
bearing and sliding fork for reassembly.
9. Remove friction disc assembly from
frame.
10. Remove three screws holding friction
disc to carrier bearing.
11. Remove old friction disc. Put the new
friction disc in place, cup side to carrier
bearing.
12. Reinstall three screws into new friction
disc and carrier bearing. Torque to
5 – 6 lbf-ft. (6.8 – 8.13 N•m).
CAUTION: Always support Sno-Thro
frame and blower housing when
loosening the cap screws holding
them together. Never loosen cap
screws while unit is in service
position.
Figure 38
1. Swing Gate
2. Swing Gate Spacer
3. Swing Gate Finger & Stop Hole
4. Drive Plate
5. Traction Idler Spring
6. Crankshaft Pulley
7. Drive Plate Spring
4
2
3
5
6
7
1
OS8246
CAUTION: Before tipping unit,
remove enough fuel so that no spills
occur.
Содержание
- Manuel du propriétaire utilisateur 1
- Owner operator manual 1
- Series sno thr 1
- Engine manual 2
- Http www ariens com 2
- Introduction 2
- Manuales en idiomas diferentes del ingles 2
- Manuals 2
- Manuels non anglais 2
- Model and serial numbers 2
- Non english manuals 2
- Table of contents 2
- Delivery 3
- Disclaimer 3
- Product registration 3
- Unauthorized replacement parts 3
- Attention 4
- Become alert 4
- Notations 4
- Obey the message 4
- Personal safety is involved 4
- Practices and laws 4
- Required operator training 4
- Safety 4
- Safety alerts 4
- Safety decals and locations 4
- Danger 5
- Emission control system 6
- Safety rules 6
- This equipment and or its engine may include exhaust and evaporative emissions control system components required to meet u s environmental protection agency epa and or california air resources board carb regulations tampering with emission controls and components by unauthorized personnel may result in severe fines or penalties emission controls and components can only be adjusted by an ariens company dealer or an authorized engine manufacturer s service center contact your ariens company equipment retailer concerning emission controls and component questions 6
- Assembly 8
- Package contents 8
- Assembly 9
- Attach upper handlebar assembly 9
- Tools required 9
- Unfold lower handlebar 9
- Connect headlight wire harness 10
- Unfold upper handlebar assembly 10
- Install discharge chute 11
- Install discharge chute crank 11
- Check function of dual handle interlock 12
- Install remote deflector cable 920014 12
- Check auger gearcase oil 13
- Check engine crankcase oil 13
- Check function of all controls 13
- Check tire pressure 13
- Fill engine fuel tank 13
- Run in attachment belt 13
- Controls and features 14
- Ariens 15
- Briggs stratton 15
- 920013 16
- Attachment clutch right hand lever 16
- Controls and features 16
- Dual handle interlock 16
- Ignition switch 920014 16
- Ignition switch push pull safety key 920013 16
- Operation 16
- Primer bulb 16
- Traction drive clutch left hand lever 16
- Choke control 17
- Electric starter 17
- Fuel shut off valve 17
- Recoil starter handle 17
- Snow clean out tool 17
- Speed selector 17
- Throttle 920014 17
- Axle lock pin 18
- Discharge chute 18
- Discharge chute crank 18
- Discharge chute deflector 18
- Remote discharge chute deflector control 920014 18
- Scraper blade 18
- Skid shoes 18
- Add fuel stabilizer to extend fuel storage life 19
- Check axle lock pins 19
- Check dual handle interlock 19
- Check function of clutches 19
- Filling fuel tank 19
- Frozen impeller 19
- Gasoline 19
- Pre start 19
- To add fuel to fuel tank 19
- Check engine fuel crankcase oil 20
- Check skid shoes 20
- Electric start 120v 20
- Manual start 20
- Starting and shut off 20
- To stop in an emergency 20
- Shut off 21
- Snow removal 21
- Tips for operation 21
- Transport 21
- Traveling 21
- Check dual handle interlock 22
- Check fasteners 22
- Maintenance 22
- Maintenance schedule 22
- Service position 22
- Auger shaft 23
- Change engine oil 23
- Check auger gearcase 23
- Check clutch operation 23
- Check engine oil 23
- Check tire pressure 23
- Clean engine 23
- General lubrication 23
- For replacement 25
- Scraper blade 25
- Service and adjustments 25
- Shear bolts 25
- Skid shoes 25
- Discharge chute 26
- Manual discharge chute deflector 920013 26
- Remote discharge deflector control adjustment 920014 26
- Attachment clutch brake adjustment 27
- Remove attachment cable slack 27
- Speed selector adjustment 27
- Check attachment idler arm roller clearance 28
- Attachment drive belt replacement 29
- Check attachment brake 29
- Check belt finger clearance 29
- Remove attachment drive belt 29
- Replace attachment drive belt 30
- Friction disc replacement 31
- Remove friction disc 31
- Traction drive belt replacement 31
- Fuel system 32
- Long term 32
- Short term 32
- Storage 32
- Accessories 33
- Add fuel stabilizer 33
- Engine will not crank start 33
- Problem probable cause correction 33
- Service parts 33
- Troubleshooting 33
- Does not operate in forward reverse 34
- Engine problems 34
- Engine stops 34
- Problem probable cause correction 34
- Small rubber beads collect in frame 34
- Troubleshooting 34
- Unit throws snow poorly or does not throw snow 34
- Specifications 35
- Specifications 36
- And chore performing equipment limited warranty 37
- Sno te 37
- Sno thr 37
- Sno thro sno tek and chore performing equipment limited warranty 37
- Special extensions 37
- Customer responsibilities 38
- Exceptions and limitations 38
- To find an authorized service representative 38
- Disclaimer 39
- Disclaimer of further warranty 39
- Exclusions items not covered by this warranty 39
- Limitation of remedy and damages 39
- Special exclusions on utility vehicles 39
- California and epa united states environmental protection agency evaporative emission control warranty statement 40
- Defects warranty requirements 40
- Manufacturer s warranty coverage 40
- Owner s warranty responsibilities 40
- Your warranty rights and obligations 40
- Disclaimer 41
- Evaporative emission warranty parts list 41
Похожие устройства
- Ariens ST24LE DELUXE Руководство пользователя
- Ariens ST28 DELUXE TRACK Руководство пользователя
- Ariens ST28DLE DELUXE Руководство пользователя
- Ariens ST28DLE PRO Руководство пользователя
- Ariens ST28DLET PRO HYDRO TRACK Руководство пользователя
- Ariens ST28DLET PRO TRACK Руководство пользователя
- Ariens ST28LET TRACK Руководство пользователя
- Ariens ST30DLE DELUXE Руководство пользователя
- Ariens SNO-TEK 28E Руководство пользователя
- Ariens POWER BRUSH 28 Руководство пользователя
- Yanmar YDP 40 STN-E Руководство пользователя
- Sdmo ST 2.36 H Руководство пользователя
- Sdmo TR 2.36 H Руководство пользователя
- Sdmo ST 3.60 H Руководство пользователя
- Sdmo TR 3.60 H Руководство пользователя
- Sdmo HP 2.26 H Руководство пользователя
- Sdmo XC 2.34 H Руководство пользователя
- Honda WMP 20 Руководство пользователя
- Gardena 3500/4E Classic Руководство пользователя
- Whirlpool AWT 2240 Таблица программ