Kohler Command PRO EFI propane PCV680 [16/96] Troubleshooting
![Kohler Command PRO EFI propane PCV740 [16/96] Troubleshooting](/views2/1597955/page16/bg10.png)
Troubleshooting
16 24 690 31 Rev. DKohlerEngines.com
Engine Cranks But Will Not Start
● Battery connected backwards.
● Blown fuse.
● Carburetor solenoid malfunction.
● Choke not closing.
● Clogged fuel line or fuel fi lter.
● Diode in wiring harness failed in open circuit mode.
● DSAI or DSAM malfunction.
● Empty fuel tank.
● Faulty electronic control unit.
● Faulty ignition coil(s).
● Faulty spark plug(s).
● Fuel pump malfunction-vacuum hose clogged or
leaking.
● Fuel shut-off valve closed.
● Ignition module(s) faulty or improperly gapped.
● Insuffi cient voltage to electronic control unit.
● Interlock switch is engaged or faulty.
● Key switch or kill switch in OFF position.
● Low oil level.
● Quality of fuel (dirt, water, stale, mixture).
● SMART-SPARK
TM
malfunction.
● Spark plug lead(s) disconnected.
Engine Starts But Does Not Keep Running
● Faulty carburetor.
● Faulty cylinder head gasket.
● Faulty or misadjusted choke or throttle controls.
● Fuel pump malfunction-vacuum hose clogged or
leaking.
● Intake system leak.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Quality of fuel (dirt, water, stale, mixture).
● Restricted fuel tank cap vent.
Engine Starts Hard
● Clogged fuel line or fuel fi lter.
● Engine overheated.
● Faulty ACR mechanism.
● Faulty or misadjusted choke or throttle controls.
● Faulty spark plug(s).
● Flywheel key sheared.
● Fuel pump malfunction-vacuum hose clogged or
leaking.
● Interlock switch is engaged or faulty.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Low compression.
● Quality of fuel (dirt, water, stale, mixture).
● Weak spark.
TROUBLESHOOTING GUIDE
When troubles occur, be sure to check simple causes which, at fi rst, may seem too obvious to be considered. For
example, a starting problem could be caused by an empty fuel tank.
Some general common causes of engine troubles are listed below and vary by engine specifi cation. Use these to
locate causing factors.
Engine Will Not Crank
● Battery is discharged.
● Faulty electric starter or solenoid.
● Faulty key switch or ignition switch.
● Interlock switch is engaged or faulty.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Pawls not engaging in drive cup.
● Seized internal engine components.
Engine Runs But Misses
● Carburetor adjusted incorrectly.
● Engine overheated.
● Faulty spark plug(s).
● Ignition module(s) faulty or improperly gapped.
● Incorrect crankshaft position sensor air gap.
● Interlock switch is engaged or faulty.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Quality of fuel (dirt, water, stale, mixture).
● Spark plug lead(s) disconnected.
● Spark plug lead boot loose on plug.
● Spark plug lead loose.
Engine Will Not Idle
● Engine overheated.
● Faulty spark plug(s).
● Idle fuel adjusting needle(s) improperly set.
● Idle speed adjusting screw improperly set.
● Inadequate fuel supply.
● Low compression.
● Quality of fuel (dirt, water, stale, mixture).
● Restricted fuel tank cap vent.
Engine Overheats
● Cooling fan broken.
● Excessive engine load.
● Fan belt failed/off .
● Faulty carburetor.
● High crankcase oil level.
● Lean fuel mixture.
● Low cooling system fl uid level.
● Low crankcase oil level.
● Radiator, and/or cooling system components clogged,
restricted, or leaking.
● Water pump belt failed/broken.
● Water pump malfunction.
Engine Knocks
● Excessive engine load.
● Hydraulic lifter malfunction.
● Incorrect oil viscosity/type.
● Internal wear or damage.
● Low crankcase oil level.
● Quality of fuel (dirt, water, stale, mixture).
Содержание
- Pcv680 pcv740 1
- Service manual 1
- Safety 2
- Maintenance 3
- Maintenance 4
- 0 0 0 80 0 039 5
- 0 0 3 1 5
- 0 65 26 0 1 55 5
- 00 0 0 0 50 5
- 1 06 engine mounting surface oil drain plug 3 8 n p t inch 5
- 1 99 13 2 0 40 5
- 16 20 unf 2b in 5
- 2 17 32 5
- 2 38 exhaust port 2 5
- 24 690 31 rev d kohlerengines com 5
- 5 15 78 5
- 5 5 93 5
- 5 9 58 5
- 7 5 36 5
- 8 14 64 5
- 8 6 66 92 8 3 25 exhaust port 1 5
- Dimensions in millimeters inch equivalents shown in 5
- Engine dimensions 5
- Engine mounting surface 5
- Engine mounting surface pto end 5
- Oil cooler 5
- Oxygen sensor spark plug 5
- Regulator assembly 5
- Regulator rectifier 5
- Specifications 5
- Specifi cations 5
- Ø 28 6 0 1 1 25 0 05 5
- Specifi cations 6
- Specifi cations 7
- Specifi cations 8
- Specifi cations 9
- Specifi cations 10
- Specifi cations 11
- Specifi cations 12
- Tools and aids 13
- Tools and aids 14
- Tools and aids 15
- Troubleshooting 16
- Troubleshooting 17
- Troubleshooting 18
- Troubleshooting 19
- Air cleaner intake 20
- Propane efi system 21
- Propane electronic fuel injection efi system 21
- Propane efi system 22
- Propane efi system 23
- Propane efi system 24
- Black connector side grey connector side ecu 25
- Pinout of ecu 25
- Propane efi system 25
- Propane efi system 26
- Propane efi system 27
- Propane efi system 28
- Propane efi system 29
- Propane efi system 30
- Propane efi system 31
- Propane efi system 32
- Propane efi system 33
- Propane efi system 34
- Propane efi system 35
- Propane efi system 36
- Propane efi system 37
- Propane efi system 38
- Propane efi system 39
- Propane efi system 40
- Propane efi system 41
- Propane efi system 42
- Propane efi system 43
- Propane efi system 44
- Propane efi system 45
- Propane efi system 46
- Propane efi system 47
- Propane efi system 48
- Propane efi system 49
- 24 690 31 rev d kohlerengines com 50
- After turning key to off wait 10 seconds before turning to on to allow ecu to go to sleep 50
- Efi diagnostic flow diagram 50
- Fuel lock off can be heard or felt to establish lock off opening fuel lock off will stay activated for one 4 6 second cycle when ecu wakes up after being asleep key on not cranking 50
- Propane efi system 50
- Start of test 50
- Lubrication system 51
- Lubrication system 52
- Electrical system 53
- Electrical system 54
- Electrical system 55
- Electrical system 56
- Electrical system 57
- Starter system 58
- Starter system 59
- Starter system 60
- Starter system 61
- Disassembly inspection and service 62
- Disassembly inspection and service 63
- Disassembly inspection and service 64
- Disassembly inspection and service 65
- Disassembly inspection and service 66
- Disassembly inspection and service 67
- Disassembly inspection and service 68
- Disassembly inspection and service 69
- Disassembly inspection and service 70
- Disassembly inspection and service 71
- Disassembly inspection and service 72
- Disassembly inspection and service 73
- Disassembly inspection and service 74
- Disassembly inspection and service 75
- Disassembly inspection and service 76
- Disassembly inspection and service 77
- Disassembly inspection and service 78
- Reassembly 79
- Reassembly 80
- Reassembly 81
- Reassembly 82
- Reassembly 83
- 690 31 rev d kohlerengines com 84
- External engine components 84
- Reassembly 84
- Reassembly 85
- Reassembly 86
- Reassembly 87
- Reassembly 88
- Reassembly 89
- Reassembly 90
- Reassembly 91
- Reassembly 92
- 2018 by kohler co all rights reserved 96
- Kohlerengines com 24 690 31 rev d 96
Похожие устройства
- Kohler Command PRO EFI propane PCV680 Руководство пользователя
- Kohler Command PRO EFI propane PCH680 Руководство по обслуживанию
- Kohler Command PRO EFI propane PCH680 Руководство пользователя
- Kohler Command PRO EFI propane PCV740 Руководство по обслуживанию
- Kohler Command PRO EFI propane PCV740 Руководство пользователя
- Kohler Command PRO EFI propane PCH740 Руководство по обслуживанию
- Kohler Command PRO EFI propane PCH740 Руководство пользователя
- Kohler Command PRO EFI propane PCV850 Руководство по обслуживанию
- Kohler Command PRO EFI propane PCV850 Руководство пользователя
- Kohler Command PRO EFI propane PCV860 Руководство по обслуживанию
- Kohler Command PRO EFI propane PCV860 Руководство пользователя
- Sokkia IM-103 Буклет
- Sokkia IM-103 Руководство пользователя
- Sokkia IM-105 Буклет
- Sokkia IM-105 Руководство пользователя
- Sokkia IM-102L Буклет
- Sokkia IM-102L Руководство пользователя
- Sokkia IM-105L Буклет
- Sokkia IM-105L Руководство пользователя
- Sokkia IM-52 Буклет