ДКС INFOLCD2000SI [48/52] Maintenance and storage

8. Maintenance and Storage

8.1 Maintenance

1. Ensure that the ventilation holes are not blocked.

2. Ensure that the UPS is not dusty.

3. Ensure that there are no traces of moisture on the UPS.

4. Perform a battery status check in accordance with section 8.3.

8.2 Storage

Connect the UPS to the mains to charge the UPS for at least 8–10 hours before storing

the UPS.

Disconnect the UPS, turn it off and place in a clean and dry place.

Temperature, °С

Период

Время зарядки

From 10 to 25

Once in 6 months

8-10 hours

From 25 to 40

Once in 3 months

8-10 hours

Table 5. Recommended battery charging frequency

Allowable storage temperature is in the range from 0 to +40 ° С.

8.3 Battery control

Batteries are the key component of the UPS. Its service life depends on the temperature,

as well as on the time of charging and discharging. High temperatures and over

discharge can shorten battery life.

1. Maintain ambient temperature in the range of 15 - 25°C.

2. In case of the UPS isn’t used for long time, it is recommended to fully charge the

batteries every 6 months.

3. Batteries should not be replaced individually.

4. Under normal working conditions, the battery life is about 2-4 years. If the batteries

were kept in a humid, dusty environment, or in low temperature conditions, their service

life will be reduced.

Algorithm of battery test are described below (battery performance may drop

dramatically as the end of its service life approaches, it is recommended to check it at

least once every 6 months):

1. Connect the UPS to the mains and charge for 8-10 hours.

2. Turn on the UPS, connect users and measure the power of their consumption.

3. Disconnect the mains so that the UPS switches to battery mode and control the

discharge time before shutting down.

4. Check whether the discharge time corresponds to the values given in figures 4 to 10.

If the discharge time decreases by more than 50%, replace the batteries.

The UPSs work with V.R.L.A. type lead-acid batteries, which are charged in the presence

of a mains supply.