![Airedale LogiCool LCC 40 [4/40] Logicool chillers](/img/pdf.png)
Airedale LogiCool LCC 40 [4/40] Logicool chillers
![Airedale LogiCool LCC 40 [4/40] Logicool chillers](/views2/1409428/page4/bg4.png)
LOGICOOL Chillers
General Statement
IMPORTANT
The information contained in this manual is critical to the correct operation and
maintenance of the unit and should be read by all persons responsible for the installation,
commissioning and maintenance of this Airedale unit.
SAFETY
The equipment has been designed and manufactured to meet international safety
standards but, like any mechanical/electrical equipment, care must be taken if you are to
obtain the best results.
CAUTION
1 Installation, service and maintenance of Airedale equipment should only be
carried out by technically trained competent personnel.
CAUTION
2 When working with any air conditioning units ensure that the electrical isolator
is switched off prior to servicing or repair work and that there is no power to
any part of the equipment.
3 Also ensure that there are no other power feeds to the unit such as fire alarm
circuits, BMS circuits etc
4 Electrical installation commissioning and maintenance work on this equipment
should be undertaken by competent and trained personnel in accordance with local
relevant standards and codes of practice.
5 Refrigerant used in this range of products is classified under the COSHH regulations
as an irritant, with set Occupational Exposure Levels (OEL) for consideration if this
plant is installed in confined or poorly ventilated areas.
6 A full hazard data sheet in accordance with COSHH regulations is available should
this be required.
SPARES
For ease of identification when ordering spares or contacting Airedale about your unit,
please quote the unit type, unit serial number and the date of manufacture, which can be
found on the unit serial plate.
A spares list for 1, 3 and 5 years will be supplied with every unit and is also available from
our Spares department on request.
SERIAL PLATE
The serial plate can be located to the inside of the control panel door, refer to Parts
Identification
section.
UK Office + 44 113 2391000 + 44 113 2507219
Unit/Gerät/Unite
LCC40
Serial/Serie/Serie
81543668-001 (63091072)
Manufactured/Hergestellt/Fabriqué
24/01/2007
Supply/Spannung/Alimentation
400 V 3 PH 50 Hz
Fuse/Hauptsicherung/Fusibles
25.0 A
Test Pressure
58.0 BAR
Prüfdruck
Pression d’essai
Refrigerant & Charge
Kältemittel und Füllung
Refrigerant & Charge
Max. operating pressure
Betriebsdruck (Maximal)
Pression de marche (Maximum)
N.B. No: 0086
www.airedale.com
4
Chillers
Installation & Maintenance : 6560544 A 06/07
Содержание
- Free cooling chiller 1
- Installation maintenance manual 1
- Kw 40 kw 1
- Logicool 1
- About airedale products customer services 2
- Logicool chillers 2
- Chillers logicool 3
- Contents 3
- General statement 4
- Logicool chillers 4
- Chillers logicool 5
- Warranty 5
- General description 6
- Logicool chillers 6
- Chillers logicool 7
- General description 7
- General description 8
- Logicool chillers 8
- Chillers logicool 9
- General description 9
- General description 10
- Logicool chillers 10
- Chillers logicool 11
- General description 11
- Front side rear 12
- Installation data 12
- Installation maintenance 6560544 a 06 07 12
- Logicool chillers 12
- The following information is for general guidance the certified drawings provided must be referred to for installation 12
- Chillers logicool 13
- Installation data 13
- Installation data 14
- Logicool chillers 14
- Chillers logicool 15
- Installation data 15
- Installation data 16
- Logicool chillers 16
- Chillers logicool 17
- Installation data 17
- B single head pump 18
- C run standby pump 18
- Ensure the system is filled with liquid then vented and the pump primed with water before running the pump this is required because the pumped liquid cools the pump bearings and mechanical seal faces 18
- Flow schemes a standard unit no pump 18
- Installation data 18
- Installation maintenance 6560544 a 06 07 18
- Logicool chillers 18
- To avoid cavitation the npsh net positive suction head incorporating a safety margin of 0 m head must be available at the pump inlet during operation 18
- When installing circulating water pumps or equipment containing them the following rules should be applied 18
- Chillers logicool 19
- Installation data 19
- Installation data 20
- Logicool chillers 20
- Chillers logicool 21
- Controls 21
- Controls 22
- Logicool chillers 22
- Chillers logicool 23
- Controls 23
- Controls 24
- Logicool chillers 24
- Chillers logicool 25
- Controls 25
- Controls 26
- Logicool chillers 26
- Chillers logicool 27
- Commissioning data 27
- 1 for glycol solutions please refer to glycol data 28
- 2 2 chiller pressure drop refers to standard unit 28
- Commissioning data 28
- Full design water flow must be maintained at all times variable water volume is not recommended and will invalidate warranty 28
- Installation maintenance 6560544 a 06 07 28
- Logicool chillers 28
- Waterflow l s 28
- Waterside pressure drop kpa 28
- Chillers logicool 29
- Commissioning data 29
- Commissioning data 30
- Lcc20 curve 1 2 30
- Lcc40 curve 3 4 30
- Logicool chillers 30
- Single head pump or run standby pump 30
- Standard standard larger 30
- Chillers logicool 31
- Commissioning data 31
- Commissioning procedure 32
- Logicool chillers 32
- Chillers logicool 33
- Commissioning procedure 33
- Commissioning procedure 34
- Logicool chillers 34
- Chillers logicool 35
- Maintenance 35
- Logicool chillers 36
- Maintenance 36
- Chillers 37
- Chillers logicool 37
- Logicool chillers 38
- Parts identification 38
- Chillers 39
- Logicool 39
- Parts identification 39
- Head office 40
Похожие устройства
- Airedale OptiChill OPC 500 Инструкция по эксплуатации
- Airedale OptiChill OPC 525 Инструкция по эксплуатации
- Airedale OptiChill OPC 550 Инструкция по эксплуатации
- Airedale OptiChill OPC 600 Инструкция по эксплуатации
- Airedale OptiChill OPC 650 Инструкция по эксплуатации
- Airedale OptiChill OPC 700 Инструкция по эксплуатации
- Airedale OptiChill OPC 750 Инструкция по эксплуатации
- Airedale OptiChill OPC 800 Инструкция по эксплуатации
- Airedale OptiChill OPC 850 Инструкция по эксплуатации
- Airedale OptiChill OPC 900 Инструкция по эксплуатации
- Airedale OptiChill OPC 950 Инструкция по эксплуатации
- Airedale OptiChill OPC 1000 Инструкция по эксплуатации
- Airedale OptiChill OPC 1100 Инструкция по эксплуатации
- Airedale TurboChill TTC1 Инструкция по эксплуатации
- Airedale UCFC 75 Инструкция по эксплуатации
- Airedale UCFC 100 Инструкция по эксплуатации
- Airedale UCFC 125 Инструкция по эксплуатации
- Juguni 0402.711 Инструкция по эксплуатации
- Airedale UCFC 150 Инструкция по эксплуатации
- Airedale UCFC 160 Инструкция по эксплуатации