![Daikin 4AMX80E7V3B [10/16] How to use reducers](/img/pdf.png)
Daikin 4AMX80E7V3B [10/16] How to use reducers
![Daikin 4AMX80E7V3B [10/16] How to use reducers](/views2/1785814/page10/bga.png)
Installation manual
7
4AMX80E7V3B
R410A Split series
4PW38479-1
HOW TO USE REDUCERS
Use the reducers supplied with the unit as described below.
Connecting a pipe of Ø12.7 to a gas pipe connection port for Ø15.9:
Connecting a pipe of Ø9.5 to a gas pipe connection port for Ø15.9:
Connecting a pipe of Ø9.5 to a gas pipe connection port for Ø12.7:
■ When using the reducer packing shown above, be careful not to
overtighten the nut, or the smaller pipe may be damaged.
(Approx. 2/3 - 1x the normal torque)
■ Apply a coat of refrigeration oil to the threaded connection port
of the outdoor unit where the flare nut comes in.
■ Use an appropriate torque wrench to avoid damaging the
connection thread by overtightening the flare nut.
PUMP DOWN OPERATION
In order to protect the environment, be sure to pump down when
relocating or disposing of the unit.
1 Remove the valve lid from liquid stop valve and gas stop valve.
2 Carry out forced cooling operation.
3 After 5 to 10 minutes, close the liquid stop valve with a
hexagonal wrench.
4 After 2-3 minutes, close the gas stop valve and stop forced
cooling operation.
Forced operation
1 Turn the operation mode switch SW2 to "COOL". (Heat pump
only)
2 Press the forced operation switch SW1 to begin forced cooling.
(See figure 5)
WARNING
■ Do not use mineral oil on flared part.
■ Prevent mineral oil from getting into the system as this
would reduce the lifetime of the units.
■ Never use piping which has been used for previous
installations. Only use parts which are delivered with
the unit.
■ Do never install a drier to this R410A unit in order to
guarantee its lifetime. The drying material may
dissolve and damage the system.
■ Incomplete flaring may cause refrigerant gas leakage.
No. 1 No. 2No. 3No. 4No. 5No. 6
Ø15.9
↓
Ø12.7
Ø12.7
↓
Ø9.5
Ø15.9
↓
Ø12.7
Ø12.7
↓
Ø9.5
Ø15.9
↓
Ø9.5
Ø15.9
↓
Ø9.5
Gasket (1) Gasket (2) Reducer and gasket
1 Inter-unit piping
2 Flare nut (for Ø15.9)
3 No. 3
4 No. 1
Be sure to attach the gasket
5 Connection port of outdoor unit
1 Flare nut (for Ø9.5)
2 No. 5
3 No. 6
Be sure to attach the gasket
1 Flare nut (for Ø12.7)
2 No. 4
3 No. 2
Be sure to attach the gasket
54 132
3 2 1
3 2 1
Flare nut Flare nut tightening torque
Ø9.5
32.7~39.9 N•m
(333~407 kgf•cm)
Ø12.7
49.5~60.3 N•m
(505~615 kgf•cm)
Ø15.9
61.8~75.4 N•m
(630~769 kgf•cm)
1 Service PCB
2 Operation mode switch SW2
3 Forced operation switch SW1
NOTE
Forced operation automatically stops
approximately 15 minutes after starting.
To continue forced operation after elapse of the 15
minutes, press the forced operation switch SW1
again.
To stop forced operation immediately, press the
forced operation switch SW1.
1
3
2
4
4
5
1 Gas stop valve
2 Close
3 Hexagonal wrench
4 Valve lid
5 Liquid stop valve
Содержание
- 1 2 3 9 3
- A kladne posúdené 3
- A pozitivně zjištěno 3
- According to the 3
- Ako je to stanovené v súbore technickej konštrukcie 3
- And judged positively by 3
- As set out in the technical construction file 3
- Atbilstoši 3
- Aufgeführt und von 3
- Bemerk 3
- Bemærk 3
- Certificatul 3
- Certifikatom 3
- Certifikatu 3
- Certifikátu 3
- Certificaat 74736 krq emc97 4957 3
- Certificado 3
- Certificado 74736 krq emc97 4957 3
- Certificat 3
- Certificate 3
- Certificato 3
- Certifikat 3
- Certifikat 74736 krq emc97 4957 3
- Conform celor stabilite în dosarul tehnic de construcţie 3
- Conformément au 3
- Daikin europe n v 3
- Daikin tcf 15 3
- De acordo com o 3
- Delineato nel file tecnico di costruzione 3
- Direktiivejä sellaisina kuin ne ovat muutettuina 3
- E com o parecer positivo de 3
- E giudicato positivamente da 3
- En in orde bevonden door 3
- En60335 2 40 3
- Et jugé positivement par 3
- F ˆ úôû èôú âù è ûùô ú â ô â óèî ù ûîâ 3
- Hinweis 3
- I henhold til 3
- I pozitivno ocijenjeno od strane 3
- Ifølge 3
- Igazolta a megfelelést a z 3
- In odobreno s strani 3
- Information 3
- Ir patvirtinta 3
- Irányelv ek és módosításaik rendelkezéseit 3
- Ja heaks kiidetud 3
- Ja jotka 3
- Jak bylo uvedeno v souboru technické konstrukce 3
- Jotka on esitetty teknisessä asiakirjassa 3
- Järgi vastavalt 3
- Kaip nurodyta techninėje konstrukcijos byloje 3
- Kako je izloženo u datoteci o tehničkoj konstrukciji 3
- Kot je določeno v tehnični mapi 3
- Krq emc97 4957 3
- Kā noteikts tehniskajā dokumentācijā 3
- Low voltage 2006 95 ec machinery safety 98 37 eec electromagnetic compatibility 89 336 eec 3
- Megjegyzés 3
- Mukaisesti 3
- Märkus 3
- Műszaki konstrukciós dokumentáció alapján a z 3
- Nagu on näidatud tehnilises dokumentatsioonis 3
- Napomena 3
- Og gjennom positiv bedømmelse av 3
- Og positivt vurderet af 3
- On hyväksynyt 3
- Opomba 3
- Osvědčením 3
- Overeenkomstig 3
- Pastaba 3
- Pažymėjimą 3
- Piezīmes 3
- Podľa 3
- Positiv ausgezeichnet gemäß 3
- Pozitīvajam lēmumam ko apliecina 3
- Poznámka 3
- Pozytywną opinią 3
- Pw25914 2b 3
- Remarque 3
- Secondo il 3
- Según el 3
- Sertifikaadile 3
- Sertifikasına 3
- Sertifikāts 3
- Sertifikaatin 3
- Sertifikat 74736 krq emc97 4957 3
- Som anført i den tekniske konstruktionsfil 3
- Som det fremkommer i den tekniske konstruksjonsfilen 3
- Som positivt intygas av 3
- Szerint 3
- Tal como estabelecido no ficheiro técnico de construção 3
- Tal como se expone en el archivo de construcción técnica 3
- Tanúsítvány 3
- Tarafından olumlu olarak değerlendirilmiştir 3
- Teknik yapı dosyasında belirtildiği gibi ve 3
- Tel que stipulé dans le fichier de construction technique 3
- Utrustningen är utförd i enlighet med den tekniska konstruktionsfilen 3
- V skladu s 3
- V souladu s 3
- Vilket också framgår av 3
- Wie in der technischen konstruktionsakte 3
- Y juzgado positivamente por 3
- Zandvoordestraat 300 b 8400 oostende belgium 3
- Zertifikat 3
- Zgodnie z archiwalną dokumentacją konstrukcyjną 3
- Zoals vermeld in het technisch constructiedossier 3
- Èûùô ôèëùèîfi 3
- Ëìâ ˆûë 3
- Ëïòóâè ìâ ôîïâèûùèî ùë â ı óë fiùè ô âíô ïèûìfi ùˆó îïèì ùèûùèîòó û ûîâ òó ûù ô ô ó ê úâù è ë úô û ïˆûë 3
- Î è îú óâù è ıâùèî fi ùô 3
- În conformitate cu 3
- Û ìêˆó ìâ ùô 3
- Świadectwem 3
- Şi apreciate pozitiv de 3
- Забележка 3
- Заявляет исключительно под свою ответственность что оборудование для кондиционирования воздуха к которому относится настоящее заявление 3
- И в соответствии с положительным решением 3
- И оценено положително от 3
- Как указано в досье технического толкования 3
- Както е заложено в акта за техническа конструкция 3
- Примечание 3
- Свидетельству 3
- Сертификат 3
- Согласно согласно 3
- Съгласно 3
- Afety precautions 4
- Installation manual 4
- Safety precautions 4
- Accessories 5
- Caution 5
- Ccessories 5
- Precautions for selecting the location 5
- Recautions for selecting the location 5
- Connections connection port 6
- Indoor outdoor unit installation drawings 6
- Installation 6
- Nstallation 6
- Outdoor unit installation drawing 6
- Precautions on installation 6
- Recautions on installation 6
- Efrigerant piping work 7
- Electing a location for installation of the indoor units 7
- Installing the outdoor unit 7
- Method for installing drain piping 7
- Outdoor unit installation guidelines 7
- Refrigerant piping work 7
- Selecting a location for installation of the indoor units 7
- Utdoor unit installation guidelines 7
- Wall facing one side 7
- Walls facing three sides 7
- Walls facing two sides 7
- Charging refrigerant 8
- Purging air and checking gas leakage 8
- Refrigerant piping 8
- Charging additional refrigerant 9
- Flaring the pipe end 9
- Important information regarding the refrigerant used 9
- Refrigerant piping work 9
- Forced operation 10
- How to use reducers 10
- Ow to use reducers 10
- Pump down operation 10
- Ump down operation 10
- Operation mode priority 11
- Priority room setting 11
- Priority room setting function 11
- Riorit 11
- Room setting 11
- Wiring 11
- Cool heat 12
- Cool heat mode lock s15 heat pump units only 12
- Heat pump units onl 12
- Ight quiet mode setting 12
- Mode loc 12
- Night quiet mode function 12
- Night quiet mode setting 12
- Est run and final check 13
- Test run and final check 13
- Wiring error check 13
- Disposal requirements 14
- Isposal requirements 14
- Items to check 14
- Pw38479 1 16
Похожие устройства
- Daikin RXL20G3V1 Инструкция по монтажу
- Daikin RXL25G3V1 Инструкция по монтажу
- Daikin RXL35G3V1B Инструкция по монтажу
- Daikin RXL35G2V1 Инструкция по монтажу
- Daikin RXG25J2V1B Инструкция по монтажу
- Daikin RXG35J2V1B Инструкция по монтажу
- Daikin RMXS112E8V1B Инструкция по монтажу
- Daikin RMXS140E8V1B Инструкция по монтажу
- Daikin RMXS112E8V1B Сервис мануал
- Daikin RMXS140E8V1B Сервис мануал
- Daikin RMXS160E8V1B Инструкция по монтажу
- Daikin RMXS160E8V1B Сервис мануал
- Daikin RMXS112E7V3B Инструкция по монтажу
- Daikin RMXS112E7V3B Сервис мануал
- Daikin RMXS140E7V3B Инструкция по монтажу
- Daikin RMXS140E7V3B Сервис мануал
- Daikin RMXS160E7V3B Инструкция по монтажу
- Daikin RMXS160E7V3B Сервис мануал
- Daikin RMXS160EV1A Технические данные
- Daikin RMXS112EV1A Технические данные