![Daikin ERRQ011AAY1 — установка и обслуживание наружного блока теплового насоса [13/22]](/img/pdf.png)
Daikin ERRQ011AAY1 — установка и обслуживание наружного блока теплового насоса [13/22]
![Daikin ERSQ016AAV1 [13/22] Vacuum drying](/views2/1799159/page13/bgd.png)
ERSQ+ERRQ011~016AAV1+Y1
Outdoor unit for air to water heat pump
4PW49635-1A
Installation manual
10
Vacuum drying
To remove all moisture from the system, proceed as follows:
1. Evacuate the system for at least 2 hours to a target vacuum of
–100.7 kPa.
2. Check that, with the vacuum pump turned off, the target vacuum
is maintained for at least 1 hour.
3. Should you fail to reach the target vacuum within 2 hours or
maintain the vacuum for 1 hour, the system may contain too
much moisture.
4. In that case, break the vacuum by pressurizing with nitrogen gas
to a gauge pressure of 0.05 MPa (0.5 bar) and repeat steps 1 to
3 until all moisture has been removed.
5. The stop valves can now be opened, and/or additional
refrigerant can be charged (see "8.3. Method for adding
refrigerant" on page 11).
7.4. Precautions when connecting field piping and
regarding insulation
■ Be careful not to let the indoor and outdoor field piping come into
contact with the compressor terminal cover.
If the liquid-side piping insulation might come into contact with it,
adjust the height as shown in the figure below. Also, make sure
the field piping does not touch the bolts or outer panels of the
compressor.
■ When the outdoor unit is installed above the indoor unit the
following can occur:
The condensated water on the stop valve can move to the
indoor unit. To avoid this, please cover the stop valve with
sealing material.
■ If the temperature is higher than 30°C and the humidity is higher
than RH 80%, then the thickness of the sealing materials should
be at least 20 mm in order to avoid condensation on the surface
of the sealing.
■ Be sure to insulate the liquid and gas-side field piping.
(The highest temperature that the gas-side piping can reach is
around 120°C, so be sure to use insulating material which is
heat resistant.)
8. CHARGING REFRIGERANT
To avoid compressor breakdown. Do not charge the refrigerant
more than the specified amount.
■ This outdoor unit is factory charged with refrigerant and
depending on pipe sizes and pipe lengths some systems require
additional charging of refrigerant. See "Calculating the additional
refrigerant charge" on page 11.
■ In case re-charge is required, refer to the nameplate of the unit.
The nameplate states the type of refrigerant and necessary
amount.
8.1. Important information regarding the refrigerant
used
This product contains fluorinated greenhouse gases covered by the
Kyoto Protocol. Do not vent gases into the atmosphere.
Refrigerant type: R410A
GWP
(1)
value: 1975
(1)
GWP = global warming potential
Please fill in with indelible ink,
■➀ the factory refrigerant charge of the product,
■➁ the additional refrigerant amount charged in the field and
■➀+➁ the total refrigerant charge
on the fluorinated greenhouse gases label supplied with the product.
The filled out label must be adhered on the inside of the product and
in the proximity of the product charging port (e.g. on the inside of the
service cover).
After opening the stop valve, it is possible that the pressure
in the refrigerant piping does not rise. This might be
caused by e.g. the closed state of the expansion valve in
the outdoor unit circuit, but does not present any problem
for correct operation of the unit.
Any exposed piping may cause condensation or burns
if touched.
2
1
3
5
5
A
4
4
6
1 Compressor
2 Ter minal cover
3 Indoor and outdoor
field piping
4 Corking, etc.
5 Insulation material
(field supply)
6 Bolts
A Be careful with pipe,
bolt and outer panel
connections
■ When servicing the unit requires the refrigerant
system to be opened, treatment and evacuation of
refrigerant must be done in accordance with relevant
local and national legislation.
■ Refrigerant cannot be charged until field wiring has
been completed.
■ Refrigerant may only be charged after performing the
leak test and the vacuum drying (see above).
■ When charging a system, care shall be taken that its
maximum permissible charge is never exceeded, in
view of the danger of liquid hammer.
■ Charging with an unsuitable substance may cause
explosions and accidents, so always ensure that the
appropriate refrigerant (R410A) is charged.
■ Refrigerant containers shall be opened slowly.
■ Always use protective gloves and protect your eyes
when charging refrigerant.
■ When performing service on the unit requiring the
refrigerant system to be opened, refrigerant must be
evacuated according to local regulations.
■ When the power is on, please close the front
panel when leaving the unit.
3
5
6
2
1
4
1 factory refrigerant charge
of the product:
see unit name plate
2 additional refrigerant
amount charged in the
field
3 total refrigerant charge
4 Contains fluorinated
greenhouse gases
covered by the Kyoto
Protocol
5 outdoor unit
6 refrigerant cylinder and
manifold for charging
Содержание
- Installation manual p.1
- Outdoor unit for air to water heat pump p.1
- L2 l2 l2 p.2
- L1 l1 l1 p.2
- D2 d2 d2 d2 d2 p.2
- D1 d1 d1 p.2
- B2 b2 b2 p.2
- B1 b1 b1 p.2
- 2 1 7 8 p.2
- Zertifikat p.3
- Och godkänts av p.3
- Directives telles que modifiées p.3
- Under iagttagelse af bestemmelserne i p.3
- Kema nb0344 p.3
- Daikin tcf 25c17 04 2009 p.3
- Som det fremkommer i p.3
- Ifølge p.3
- Ar pilnu atbildību apliecina ka tālāk aprakstītās iekārtas uz kurām attiecas šī deklarācija p.3
- Декларира на своя отговорност че оборудването за което се отнася тази декларация p.3
- Pozytywną opinią p.3
- Enligt villkoren i p.3
- Za předpokladu že jsou využívány v souladu s našimi pokyny odpovídají následujícím normám nebo normativním dokumentům p.3
- Ob upoštevanju določb p.3
- Directives as amended p.3
- Un atbilstoši p.3
- Kako je izloženo u p.3
- Daikin europe n v p.3
- Som anført i p.3
- Ievērojot prasības kas noteiktas p.3
- And judged positively by p.3
- В соответствии с положениями p.3
- Poznámka p.3
- Enligt p.3
- Za dodržení ustanovení předpisu p.3
- Noudattaen määräyksiä p.3
- Directivelor cu amendamentele respective p.3
- U skladu sa slijedećim standardom ima ili drugim normativnim dokumentom ima uz uvjet da se oni koriste u skladu s našim uputama p.3
- Kaip nustatyta p.3
- Da belirtildiği gibi ve p.3
- Съответстват на следните стандарти или други нормативни документи при условие че се използват съгласно нашите инструкции p.3
- Smjernice kako je izmijenjeno p.3
- I pozitivno ocijenjeno od strane p.3
- Alapján a z p.3
- Şi apreciat pozitiv de p.3
- Pozitīvajam vērtējumam saskaņā ar p.3
- En60335 2 40 p.3
- Napomena p.3
- Directivas según lo enmendado p.3
- Teljes felelőssége tudatában kijelenti hogy a berendezések melyekre e nyilatkozat vonatkozik p.3
- Järgi vastavalt p.3
- Conformément aux stipulations des p.3
- Съгласно p.3
- Smernice v platnom znení p.3
- I henhold til p.3
- Ako bolo uvedené v p.3
- Ürünün talimatlarımıza göre kullanılması koşuluyla aşağıdaki standartlar ve norm belirten belgelerle uyumludur p.3
- Positiv beurteilt gemäß p.3
- En positief beoordeeld door p.3
- Z vso odgovornostjo izjavlja da je oprema naprav na katero se izjava nanaša p.3
- Tel que défini dans p.3
- Jotka on esitetty asiakirjassa p.3
- Conformément au p.3
- Соответствуют следующим стандартам или другим нормативным документам при условии их использования согласно нашим инструкциям p.3
- Skladni z naslednjimi standardi in drugimi normativi pod pogojem da se uporabljajo v skladu z našimi navodili p.3
- Hinweis p.3
- According to the according to the p.3
- Û ìêˆó ìâ ùô p.3
- Piezīmes p.3
- E giudicato positivamente da p.3
- Z późniejszymi poprawkami p.3
- Nagu on näidatud dokumendis p.3
- Directivas conforme alteração em p.3
- Tarafından tarafından olumlu olarak değerlendirildiği gibi p.3
- Jiro tomita director quality assurance ostend 2nd of june 2009 p.3
- Conform de volgende norm en of één of meer andere bindende documenten zijn op voorwaarde dat ze worden gebruikt overeenkomstig onze instructies p.3
- Согласно p.3
- Siguiendo las disposiciones de p.3
- Gitt i henhold til bestemmelsene i p.3
- A pozitívne zistené p.3
- În urma prevederilor p.3
- Pastaba p.3
- E com o parecer positivo de p.3
- Y es valorado positivamente por p.3
- Märkus p.3
- Dichiara sotto la propria responsabilità che gli apparecchi a cui è riferita questa dichiarazione p.3
- Tanúsítvány p.3
- Jak bylo uvedeno v p.3
- Como se establece en p.3
- Следвайки клаузите на p.3
- Sertifikasına p.3
- Gemäß den vorschriften der p.3
- A pozitivně zjištěno p.3
- În conformitate cu p.3
- Pagal pagal p.3
- Direttive come da modifica p.3
- Wie in der p.3
- Mukaisesti p.3
- Değiştirilmiş halleriyle yönetmelikler p.3
- Tamamen kendi sorumluluğunda olmak üzere bu bildirinin ilgili olduğu donanımının aşağıdaki gibi olduğunu beyan eder p.3
- Ja jotka p.3
- Certificate p.3
- Примечание p.3
- Secondo le prescrizioni per p.3
- Following the provisions of p.3
- 551 qua emc p.3
- Î è îú óâù è ıâùèî fi ùô p.3
- Overholder følgende standard er eller andet andre retningsgivende dokument er forudsat at disse anvendes i henhold til vore instrukser p.3
- Direktīvās un to papildinājumos p.3
- Vyhlasuje na vlastnú zodpovednosť že zariadenie na ktoré sa vzťahuje toto vyhlásenie p.3
- Megjegyzés p.3
- Der den folgenden norm en oder einem anderen normdokument oder dokumenten entspricht entsprechen unter der voraussetzung daß sie gemäß unseren anweisungen eingesetzt werden p.3
- Tal como estabelecido em p.3
- Ja heaks kiidetud p.3
- Bunun koşullarına uygun olarak p.3
- Както е изложено в p.3
- Secondo il p.3
- F ˆ î ıôú âù è ûùô p.3
- Ìâ ù úëûë ùˆv è ù íâˆv ùˆv p.3
- Overeenkomstig de bepalingen van p.3
- Direktyvose su papildymais p.3
- Visiška savo atsakomybe skelbia kad įranga kuriai taikoma ši deklaracija p.3
- Megfelelnek az alábbi szabvány ok nak vagy egyéb irányadó dokumentum ok nak ha azokat előírás szerint használják p.3
- Delineato nel p.3
- Как указано в p.3
- Richtlijnen zoals geamendeerd p.3
- Et évalué positivement par p.3
- Ëïòóâè ìâ ôîïâèûùèî ùë â ı óë fiùè ô âíô ïèûìfi ûùôó ô ô ô ó ê úâù è ë úô û ïˆûë p.3
- Overeenkomstig p.3
- Direktiver med senere ændringer p.3
- Verklaart hierbij op eigen exclusieve verantwoordelijkheid dat de apparatuur waarop deze verklaring betrekking heeft p.3
- Low voltage 2006 95 ec machinery 98 37 ec till 29 12 2009 electromagnetic compatibility 2004 108 ec p.3
- Deklaruje na własną wyłączną odpowiedzialność że urządzenia których ta deklaracja dotyczy p.3
- Tad ja lietoti atbilstoši ražotāja norādījumiem atbilst sekojošiem standartiem un citiem normatīviem dokumentiem p.3
- Izjavljuje pod isključivo vlastitom odgovornošću da oprema na koju se ova izjava odnosi p.3
- Bemærk p.3
- И оценено положително от p.3
- Respektive utstyr er i overensstemmelse med følgende standard er eller andre normgivende dokument er under forutssetning av at disse brukes i henhold til våre instrukser p.3
- Estão em conformidade com a s seguinte s norma s ou outro s documento s normativo s desde que estes sejam utilizados de acordo com as nossas instruções p.3
- Ëìâ ˆûë p.3
- Opomba p.3
- Direktiver med foretatte endringer p.3
- Vastavalt nõuetele p.3
- Laikantis nuostatų pateikiamų p.3
- Deklarerar i egenskap av huvudansvarig att utrustningen som berörs av denna deklaration innebär att p.3
- Sú v zhode s nasledovnou ými normou ami alebo iným i normatívnym i dokumentom ami za predpokladu že sa používajú v súlade s našim návodom p.3
- Irányelv ek és módosításaik rendelkezéseit p.3
- Bemerk p.3
- И в соответствии с положительным решением p.3
- Respektive utrustning är utförd i överensstämmelse med och följer följande standard er eller andra normgivande dokument under förutsättning att användning sker i överensstämmelse med våra instruktioner p.3
- Están en conformidad con la s siguiente s norma s u otro s documento s normativo s siempre que sean utilizados de acuerdo con nuestras instrucciones p.3
- Ëáèòv fi ˆ ô ó ùúô ô ôèëıâ p.3
- On vastavuses järgmis t e standardi te ga või teiste normatiivsete dokumentidega kui neid kasutatakse vastavalt meie juhenditele p.3
- Direktiven gemäß änderung p.3
- Vastaavat seuraavien standardien ja muiden ohjeellisten dokumenttien vaatimuksia edellyttäen että niitä käytetään ohjeidemme mukaisesti p.3
- La declaración p.3
- Declară pe proprie răspundere că echipamentele la care se referă această declaraţie p.3
- Szerint p.3
- Ir kaip teigiamai nuspręsta p.3
- Aşa cum este stabilit în p.3
- Заявляет исключительно под свою ответственность что оборудование к которому относится настоящее заявление p.3
- Remarque p.3
- Ersq011aav1 ersq014aav1 ersq016aav1 ersq011aay1 ersq014aay1 ersq016aay1 errq011aav1 errq014aav1 errq016aav1 errq011aay1 errq014aay1 errq016aay1 p.3
-  ó è û ìêˆó ìâ ùô îfiïô ıô úfiù ô ïïô ááú êô î óôóèûìòó fi ùëó úô fiıâûë fiùè úëûèìô ôèô óù è û ìêˆó ìâ ùè ô ëá â ì p.3
- On hyväksynyt p.3
- Direktive z vsemi spremembami p.3
- V súlade s p.3
- Kā norādīts p.3
- Declara bajo su única responsabilidad que el equipo al que hace p.3
- Sunt în conformitate cu următorul următoarele standard e sau alt e document e normativ e cu condiţia ca acestea să fie utilizate în conformitate cu instrucţiunile noastre p.3
- Information p.3
- Aufgeführt und von p.3
- Забележка p.3
- Pw40544 5d p.3
- Erklærer som eneansvarlig at udstyret som er omfattet af denne erklæring p.3
- Zoals vermeld in p.3
- Og positivt vurderet af p.3
- Direktiv med företagna ändringar p.3
- V souladu s p.3
- Követi a z p.3
- De acuerdo con el p.3
- Spełniają wymogi następujących norm i innych dokumentów normalizacyjnych pod warunkiem że używane są zgodnie z naszymi instrukcjami p.3
- In odobreno s strani p.3
- Atitinka žemiau nurodytus standartus ir arba kitus norminius dokumentus su sąlyga kad yra naudojami pagal mūsų nurodymus p.3
- Zgodnie z postanowieniami dyrektyw p.3
- Og gjennom positiv bedømmelse av p.3
- Direktiivid koos muudatustega p.3
- V skladu s p.3
- Kot je določeno v p.3
- De acordo com o previsto em p.3
- Sont conformes à la aux norme s ou autre s document s normatif s pour autant qu ils soient utilisés conformément à nos instructions p.3
- Ilmoittaa yksinomaan omalla vastuullaan että tämän ilmoituksen tarkoittamat laitteet p.3
- As set out in p.3
- Директиви с техните изменения p.3
- Prohlašuje ve své plné odpovědnosti že zařízení k němuž se toto prohlášení vztahuje p.3
- Erklærer et fullstendig ansvar for at det utstyr som berøres av denne deklarasjon innebærer at p.3
- Zgodnie z dokumentacją p.3
- Održiavajúc ustanovenia p.3
- Direktiivejä sellaisina kuin ne ovat muutettuina p.3
- V platném znění p.3
- Kinnitab oma täielikul vastutusel et käesoleva deklaratsiooni alla kuuluv varustus p.3
- De acordo com o p.3
- Sono conformi al i seguente i standard s o altro i documento i a carattere normativo a patto che vengano usati in conformità alle nostre istruzioni p.3
- Igazolta a megfelelést a z p.3
- Are in conformity with the following standard s or other normative document s provided that these are used in accordance with our instructions p.3
- Директив со всеми поправками p.3
- Prema odredbama p.3
- Erklärt auf seine alleinige verantwortung dass die ausrüstung für die diese erklärung bestimmt ist p.3
- Ntroduction p.4
- Installation manual p.4
- Warning p.5
- Model identification p.5
- Ccessories p.5
- Caution p.5
- Afety considerations p.5
- Selecting installation location p.6
- Nstallation of the unit p.6
- Selecting a location in cold climates p.7
- Precautions on installation p.7
- Dimensions and servicing space p.7
- Method for removing transportation stay p.8
- Installing the unit p.8
- Installation method for prevention of falling over p.8
- Inspecting handling and unpacking the unit p.8
- Handling the unit p.8
- Drain work p.8
- Precautions for r410a p.8
- Selection of piping material p.9
- Refrigerant pipe size p.9
- Installation p.9
- Guidelines for necessity of a trap p.9
- Efrigerant pipe size and allowable pipe length p.9
- Allowable pipe length and height difference p.9
- Recautions on refrigerant piping p.10
- Guidelines for flare connection p.10
- Guidelines for brazing p.10
- Tightening torques p.11
- Opening closing the stop valve p.11
- Guidelines for handling stop valve p.11
- Cautions on handling the stop valve cover p.11
- Cautions on handling the stop valve p.11
- Cautions on handling the service port p.11
- Refrigerant piping p.12
- Preventing foreign objects from entering p.12
- Leak test and vacuum drying p.12
- Leak test p.12
- Iping connection work p.12
- General guidelines p.12
- Vacuum drying p.13
- Precautions when connecting field piping and regarding insulation p.13
- Important information regarding the refrigerant used p.13
- Harging refrigerant p.13
- Precautions when adding r410a p.14
- Method for adding refrigerant p.14
- How to connect the tank p.14
- Complete recharging p.14
- Charging while the outdoor unit is at a standstill p.14
- Calculating the additional refrigerant charge p.14
- Precautions on electrical wiring work p.15
- Lectrical wiring work p.15
- Internal wiring parts table p.15
- System overview of field wiring p.16
- Precautions on wiring of power supply and inter unit wiring p.16
- Specifications of standard wiring components p.17
- Field line connection control wiring p.17
- Up and configuration p.18
- Test run p.18
- Pre operation checks p.18
- Final check p.18
- Est operation and final check p.18
- Service precautions p.19
- Service mode operation p.19
- Refrigerant recovery operation method by a refrigerant reclaimer p.19
- Aintenance and servicing p.19
- W x x x x x c p.19
- W x x x x c x p.19
- W x w x w x w p.19
- Vacuuming method p.19
- Setting the mode p.19
- X c x x x x w p.20
- X c x x x w w p.20
- X c x x w w w p.20
- X c x w w w w p.20
- X c w w w w w p.20
- Technical specifications p.20
- Pump down operation p.20
- Nit specifications p.20
- Isposal requirements p.20
- Electrical specifications p.20
Похожие устройства
-
Daikin 3AMXM52N2V1B9Руководство по применению для установщика -
Daikin 3AMXM52N2V1B9Инструкция по монтажу -
Daikin 4MXM80N2V1B9Руководство по применению для установщика
-
Daikin 4MXM80N2V1B9Инструкция по монтажу
-
Daikin 4MXM68N2V1B9Руководство по применению для установщика
-
Daikin 4MXM68N2V1B9Инструкция по монтажу
-
Daikin ERRQ016AAY1Технические данные -
Daikin ERRQ016AAY1Инструкция по монтажу -
Daikin ERRQ014AAY1Технические данные
-
Daikin ERRQ014AAY1Инструкция по монтажу
-
Daikin ERRQ011AAY1Технические данные
-
Daikin ERSQ016AAY1Технические данные
Подробное руководство по установке и обслуживанию наружного блока теплового насоса. Узнайте, как правильно проводить вакуумирование и зарядку хладагента.