Kohler Command PRO EFI propane PCV860 [21/108] Troubleshooting
![Kohler Command PRO EFI propane PCV860 [21/108] Troubleshooting](/views2/1597975/page21/bg15.png)
2119 690 02 Rev. C KohlerEngines.com
Troubleshooting
Engine Cranks But Will Not Start
● Battery connected backwards.
● Blown fuse.
● Carburetor solenoid malfunction.
● Choke not closing.
● Clogged fuel line or fuel fi lter.
● Diode in wiring harness failed in open circuit mode.
● DSAI or DSAM malfunction.
● Empty fuel tank.
● Faulty electronic control unit.
● Faulty ignition coil(s).
● Faulty spark plug(s).
● Fuel pump malfunction-vacuum hose clogged or
leaking.
● Fuel shut-off valve closed.
● Ignition module(s) faulty or improperly gapped.
● Insuffi cient voltage to electronic control unit.
● Interlock switch is engaged or faulty.
● Key switch or kill switch in OFF position.
● Low oil level.
● Quality of fuel (dirt, water, stale, mixture).
● SMART-SPARK
TM
malfunction.
● Spark plug lead(s) disconnected.
Engine Starts But Does Not Keep Running
● Faulty carburetor.
● Faulty cylinder head gasket.
● Faulty or misadjusted choke or throttle controls.
● Fuel pump malfunction-vacuum hose clogged or
leaking.
● Intake system leak.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Quality of fuel (dirt, water, stale, mixture).
● Restricted fuel tank cap vent.
Engine Starts Hard
● Clogged fuel line or fuel fi lter.
● Engine overheated.
● Faulty ACR mechanism.
● Faulty or misadjusted choke or throttle controls.
● Faulty spark plug(s).
● Flywheel key sheared.
● Fuel pump malfunction-vacuum hose clogged or
leaking.
● Interlock switch is engaged or faulty.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Low compression.
● Quality of fuel (dirt, water, stale, mixture).
● Weak spark.
TROUBLESHOOTING GUIDE
When troubles occur, be sure to check simple causes which, at fi rst, may seem too obvious to be considered. For
example, a starting problem could be caused by an empty fuel tank.
Some general common causes of engine troubles are listed below and vary by engine specifi cation. Use these to
locate causing factors.
Engine Will Not Crank
● Battery is discharged.
● Faulty electric starter or solenoid.
● Faulty key switch or ignition switch.
● Interlock switch is engaged or faulty.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Pawls not engaging in drive cup.
● Seized internal engine components.
Engine Runs But Misses
● Carburetor adjusted incorrectly.
● Engine overheated.
● Faulty spark plug(s).
● Ignition module(s) faulty or improperly gapped.
● Incorrect crankshaft position sensor air gap.
● Interlock switch is engaged or faulty.
● Loose wires or connections that intermittently ground
ignition kill circuit.
● Quality of fuel (dirt, water, stale, mixture).
● Spark plug lead(s) disconnected.
● Spark plug lead boot loose on plug.
● Spark plug lead loose.
Engine Will Not Idle
● Engine overheated.
● Faulty spark plug(s).
● Idle fuel adjusting needle(s) improperly set.
● Idle speed adjusting screw improperly set.
● Inadequate fuel supply.
● Low compression.
● Quality of fuel (dirt, water, stale, mixture).
● Restricted fuel tank cap vent.
Engine Overheats
● Cooling fan broken.
● Excessive engine load.
● Fan belt failed/off .
● Faulty carburetor.
● High crankcase oil level.
● Lean fuel mixture.
● Low cooling system fl uid level.
● Low crankcase oil level.
● Radiator, and/or cooling system components clogged,
restricted, or leaking.
● Water pump belt failed/broken.
● Water pump malfunction.
Engine Knocks
● Excessive engine load.
● Hydraulic lifter malfunction.
● Incorrect oil viscosity/type.
● Internal wear or damage.
● Low crankcase oil level.
● Quality of fuel (dirt, water, stale, mixture).
Содержание
- Pcv850 pcv860 service manual 1
- Safety 2
- Maintenance 3
- Maintenance 4
- Specifications 5
- Specifi cations 5
- Specifi cations 6
- Specifi cations 7
- Specifi cations 8
- Specifi cations 9
- Specifi cations 10
- Specifi cations 11
- Specifi cations 12
- Specifi cations 13
- Specifi cations 14
- Specifi cations 15
- Specifi cations 16
- Specifi cations 17
- Tools and aids 18
- Tools and aids 19
- Tools and aids 20
- Troubleshooting 21
- Troubleshooting 22
- Troubleshooting 23
- Troubleshooting 24
- Air cleaner intake 25
- Propane efi system 26
- Propane electronic fuel injection efi system 26
- Propane efi system 27
- Propane efi system 28
- Propane efi system 29
- Black connector side grey connector side ecu 30
- Pinout of ecu 30
- Propane efi system 30
- Propane efi system 31
- Propane efi system 32
- Propane efi system 33
- Propane efi system 34
- Propane efi system 35
- Propane efi system 36
- Propane efi system 37
- Propane efi system 38
- Propane efi system 39
- Propane efi system 40
- Propane efi system 41
- Propane efi system 42
- Propane efi system 43
- Propane efi system 44
- Propane efi system 45
- Propane efi system 46
- Propane efi system 47
- Propane efi system 48
- Propane efi system 49
- 19 690 02 rev c kohlerengines com 50
- After turning key to off wait 10 seconds before turning to on to allow ecu to go to sleep 50
- Efi diagnostic flow diagram 50
- Fuel lock off can be heard or felt to establish lock off opening fuel lock off will stay activated for one 4 6 second cycle when ecu wakes up after being asleep key on not cranking 50
- Propane efi system 50
- Start of test 50
- Governor system 51
- Governor system 52
- Governor system 53
- Governor system 54
- Governor system 55
- Governor system 56
- Governor system 57
- Governor system 58
- Operation input voltage 0 1 volts at idle 9 volts at high speed 58
- Governor system 59
- Governor system 60
- Lubrication system 61
- Lubrication system 62
- Electrical system 63
- Electrical system 64
- Electrical system 65
- Electrical system 66
- Electrical system 67
- Starter system 68
- Starter system 69
- Starter system 70
- Starter system 71
- Disassembly inspection and service 72
- Disassembly inspection and service 73
- Disassembly inspection and service 74
- Disassembly inspection and service 75
- Disassembly inspection and service 76
- Disassembly inspection and service 77
- Disassembly inspection and service 78
- Disassembly inspection and service 79
- Disassembly inspection and service 80
- Disassembly inspection and service 81
- Disassembly inspection and service 82
- Disassembly inspection and service 83
- Disassembly inspection and service 84
- Disassembly inspection and service 85
- Disassembly inspection and service 86
- Disassembly inspection and service 87
- Disassembly inspection and service 88
- Disassembly inspection and service 89
- Disassembly inspection and service 90
- Reassembly 91
- Reassembly 92
- Reassembly 93
- Reassembly 94
- Reassembly 95
- Reassembly 96
- Reassembly 97
- Reassembly 98
- Reassembly 99
- Reassembly 100
- Reassembly 101
- Reassembly 102
- Reassembly 103
- Reassembly 104
- Reassembly 105
- 2017 by kohler co all rights reserved 108
- Kohlerengines com 19 690 02 rev c 108 108
Похожие устройства
- Kohler Command PRO EFI propane PCV860 Руководство пользователя
- Sokkia IM-103 Буклет
- Sokkia IM-103 Руководство пользователя
- Sokkia IM-105 Буклет
- Sokkia IM-105 Руководство пользователя
- Sokkia IM-102L Буклет
- Sokkia IM-102L Руководство пользователя
- Sokkia IM-105L Буклет
- Sokkia IM-105L Руководство пользователя
- Sokkia IM-52 Буклет
- Sokkia IM-52 Руководство пользователя
- Sokkia IM-55 Буклет
- Sokkia IM-55 Руководство пользователя
- Sokkia FX-101 Буклет
- Sokkia FX-101 Краткое справочное руководство
- Sokkia FX-101 Руководство по эксплуатации
- Sokkia FX-102 Буклет
- Sokkia FX-102 Краткое справочное руководство
- Sokkia FX-102 Руководство по эксплуатации
- Sokkia FX-105 Буклет